Member Since: 30 Dec 2005
Location: Hillarys, Perth
Posts: 51
Low Coolant Warning
Had the coolant bottle changed a few months ago but have started getting Low Coolant message again, if the bottle needs topping up does it mean there is a leak? surely it is a sealed system and should not loose liquid? Going in for service on Monday so hopefully get sorted then, any comments before hand would be useful (comments about this topic that is!!!!)2005 Disco 3 HSE in Zambezi + Ebony, Sat Nav, Active Locking Rear Diff and Cool Box
11th Jan 2007 12:18 am
Gareth Site Moderator
Member Since: 07 Dec 2004
Location: Bramhall
Posts: 26772
I had a bottle replaced, and still got the warning, then I checked and added coolant, no problem since.
If the level has dropped significantly then you need to get the system pressure tested for leaks.
If the level is in between the high and low marks then the sensor in the bottle maybe faulty. It is a known problem and the bottle is usually replaced. Mine had this fault.
Chris2011 Discovery 4 (MY12) SDV6 HSE with General Grabber AT's, Traxide Aux Battery system, custom rear drawers and Autosafe half height cargo barrier
Gone - 2005 Discovery 3 TDV6 HSE
ARB Bull Bar, Warn 9.5XP Winch, IPF D/Lights, Cooper STT's, LR Raised Air Intake, Traxide aux battery system, custom drawers and half height Autosafe cargo barrier, Mitchell Bros 4x4 tow hitch
This has been happening in the RRS too. There is a TSB on it below:-
Quote:
TSB# LS303-006
SECTION: 303-03
"Low Coolant Level" Message or Warning Lamp Illuminated
AFFECTED VEHICLE RANGE:
Range Rover Sport (LS) VIN: 6A900129 to 6A929342
CONDITION SUMMARY:
"LOW COOLANT LEVEL" MESSAGE OR WARNING LAMP ILLUMINATED
Situation: A customer may report that the "Low Coolant" amber warning lamp is illuminated or a "Low Coolant Level" message is displayed in the Message Center when the engine coolant expansion tank volume is within recommended levels.
The coolant level float in the expansion tank can absorb coolant causing the float to sink. The warning lamp and message will display when the float sinks below the low level sensor trigger point.
Action: Should a customer express a concern related to the above condition, within the specified VIN range, refer to the Repair Procedure detailed in this bulletin.
PARTS:
NOTE: The current expansion tank part PCF500015 may be used only if the sticker on the side of the part has a date of 31-10-05 (DD-MM-YY) or later. A newer part PCF500090 may be used when available.
PCF500015..............Coolant expansion tank (dated 31-10-05 or later) Qty 1
PCF500090..............Coolant expansion tank Qty 1
They may have actually replaced your coolant bottle with another faulty one!
Land Rover Australia have a policy (like all car makers) to quit the stock on the shelf first -FIFO.Have a nice day!
2010 Cayenne Diesel with PASM & Off Road Pkg
2005 HSE D3 (Sold)
The Mrs. LR3 is having the coolant problem - but it's an '07. From researching the topic it looked like most of the posts were for '05's. Any '07 owners out there having this problem?
In any case, I'll take what I learned and visit the stealers.
Slightly here - but when we had the LR3 in for the coolant problem we asked the stealer to fix the rattling of the LR DVD - they fixed it all right - no more rattling....now we have no power to the unit....adding it to the list2007 LR3 HSE - Zermatt Silver
2007 LR3 HSE - Stornoway Gray (Mrs.)
*Luxury Package (Heated Wind Shield, Heated Seats, Heated Washer Fluid, Adaptive Front Lights and Center Console Cooler Box)*
13th Jan 2008 3:08 am
WOODY179
Member Since: 01 Jun 2005
Location: Chesterfield
Posts: 3654
Gareth wrote:
I had a bottle replaced, and still got the warning, then I checked and added coolant, no problem since.
Don't presume its wrong, you may need a top up.
Same here, had the coolant bottle replaced, next day got low coolant message, took it to the dealer (they are only a couple of miles down the road) and they topped it up again. Happened again after a few more days, rang them and they said to top it up again as it probably had an air lock which had sorted it self out, since then its's been fine, although they did check the level and strength (with out me asking) last time it was in.1996 Discovery 1 300TDI ES Biarritz Blue, sold
1999 Discovery 2 TD5 ES Rioja Red, sold
2002 Discovery 2 TD5 ES Buckingham Blue, sold
2005 Discovery 3 TDV6 HSE Adriatic Blue, sold
2006 Discovery 3 TDV6 HSE Zambezi Silver, sold
2011 Discovery 4 SDV6 HSE Nara Bronze, sold
2016 Volvo XC60 D5 AWD Lux Nav Twilight Bronze, sold
2020 Range Rover Evoque P250 First Edition, Nolita grey, sold
2023 Range Rover Evoque P300e Autobiography, Carpathian grey
13th Jan 2008 2:13 pm
Maciek
Member Since: 13 Jan 2008
Location: Warsaw
Posts: 1
Re: Low Coolant Warning
discodownunder wrote:
Had the coolant bottle changed a few months ago but have started getting Low Coolant message again, if the bottle needs topping up does it mean there is a leak? surely it is a sealed system and should not loose liquid? Going in for service on Monday so hopefully get sorted then, any comments before hand would be useful (comments about this topic that is!!!!)
A few months ago I had a similar situation, only my coolant level was dipping at a rate of 1 l per 100 kms. The issue was somewhat more serious - there was a leak within the EGR valva radiator - they queried LR UK and said it was the first it had happened - have your cooling system thouroughly checked.
Cheers
8)
M.
13th Jan 2008 8:34 pm
nobbyclark
Member Since: 03 May 2005
Location: Perth, Scotland
Posts: 1268
I have an 05 and got this when driving home last w/e. Shouldn't the coolant have been topped up at the service, which I had a few weeks ago? If so, I wouldn't expect it to be reporting it to be low after less than 1k miles.No longer a D3 owner but still subscribed to multiple threads!
14th Jan 2008 5:19 am
DN D3 Decade
Member Since: 23 Jun 2006
Location: W.London.
Posts: 2344
What I found is that the level can be seen to be ok, but the float (level sensor) absorbs coolant gradually, so the level may drop very slightly over many months, until the float has absorbed enough coolant to cause it to sink. That's when you start to get the 'Low Coolant' messages, and hopefully the dealer should then replace the coolant header bottle assy for you. Mine was 'loosing' small amounts of coolant for ages, dealer wouldn't do anything other than pressure check it for leaks, until messages started appearing.
14th Jan 2008 11:40 am
Jas3
Member Since: 17 May 2024
Location: Dublin
Posts: 8
Hello I'm new to forum, so hi to everyone,
I've just bought a 2007 disco, and Ive low coolant warning...
In expansion tank, I've looked and looked and can't find the min to max marker..
Any help would be great...
17th May 2024 9:34 am
LittleG
Member Since: 21 Sep 2013
Location: Wombourne
Posts: 392
This is a photo of my old header, you can make out the cold fill range.
Click image to enlarge
Hope it helps.
17th May 2024 10:25 am
Jas3
Member Since: 17 May 2024
Location: Dublin
Posts: 8
You cannot post new topics in this forum You cannot reply to topics in this forum You cannot edit your posts in this forum You cannot delete your posts in this forum You cannot vote in polls in this forum
here - but when we had the LR3 in for the coolant problem we asked the stealer to fix the rattling of the LR DVD - they fixed it all right - no more rattling....now we have no power to the unit....adding it to the list
