Member Since: 02 Jul 2006
Location: Oberon, NSW
Posts: 6922
DSL wrote:
I've tried 2 plumbing supplies and a B&Q Warehouse place for a 40mm test plug, with no luck. Anyone know of a source on the web??
They are made in the U.K.
You anywhere near Willenhall?
or give them a ring.
http://www.horobin.co.uk/steeltestplugsingleseal.htm
I've put this link in the Sticky. “There are only three sports: bullfighting, motor racing, and mountaineering; all the rest are merely gamesâ€
Ernest Hemmingway
D4 3.0 Active Diff, Adaptive Lights, High Beam Assist, Surround Cameras, Privacy Glass.
D3 2.7:Adaptive Headlights,Electronic Rear Diff,ARB Bar,Blaupunkt Speakers,JVC Powered Subwoofer,Removable Snorkel,Mitch Hitch,Pioneer After Market Head Unit,Steering Wheel Control Adaptor,Remote Adjustable Supension Rod System, Taxside Dual Battery System.
21st Jan 2007 11:13 pm
DSL Keeper of the wheelie bin
Member Since: 11 May 2006
Location: Off again! :-)
Posts: 73121
AndrewS wrote:
DSL push harder
Tell my wife that!!! She was in charge of the bung when I was on the exhaust tube & vice versa, hence not getting a good enough seal.
CaverD3, cheers, will give them a ring.
22nd Jan 2007 12:23 pm
catweasel
Member Since: 05 May 2006
Location: Bundaleer
Posts: 4805
DSL wrote:
rubber piece could do with being couple of cm longer
You should have shoved here lips a bit closer to get a beter seal Home of RLD Hidden winch mounts Spare wheel Locks Trailer Body Fabrication ray@rld-tech.co.uk D3/4 sump plates MY 14 sump plates and the Discovery Sport wheel protectors Discovery 5 wheel locks
more Helsport tents and other things for camping Law of Mechanical Repair:
"After your hands are coated with grease, your nose will begin to itch and you'll have to pee!"
22nd Jan 2007 5:58 pm
DSL Keeper of the wheelie bin
Member Since: 11 May 2006
Location: Off again! :-)
Posts: 73121
no offence only a joke Home of RLD Hidden winch mounts Spare wheel Locks Trailer Body Fabrication ray@rld-tech.co.uk D3/4 sump plates MY 14 sump plates and the Discovery Sport wheel protectors Discovery 5 wheel locks
more Helsport tents and other things for camping Law of Mechanical Repair:
"After your hands are coated with grease, your nose will begin to itch and you'll have to pee!"
22nd Jan 2007 8:25 pm
DSL Keeper of the wheelie bin
Member Since: 11 May 2006
Location: Off again! :-)
Posts: 73121
I knew that!
Phoned Horobin above & they didn't think their plugs would withstand the pressure (40mm one rated to 30psi). also that the rubber is only natural rubber & would melt if in contact with a hot exhaust.
The quest continues!
30th Jan 2007 11:44 am
caverD3
Member Since: 02 Jul 2006
Location: Oberon, NSW
Posts: 6922
DSL,
They are talking cr p .
It sounds like they don't want to take reponsability because their plug is not designed for this, if it fails or causes engine problems. The plugs look the same as mine, and mine works fine, even if t is not a complete seal it will still alow enough pressure for the jack. The exhaust tip will have cooled by the time you use it and if it is sealed no hot gases will come into contact with it. If you use a sleave of rubber its not in contact anyway. If you can hold a bung in by hand I can't see this plug failing when used in this situation.
You are using it at your own risk,get one and try it, they aren't pricey anyway.“There are only three sports: bullfighting, motor racing, and mountaineering; all the rest are merely gamesâ€
Ernest Hemmingway
D4 3.0 Active Diff, Adaptive Lights, High Beam Assist, Surround Cameras, Privacy Glass.
D3 2.7:Adaptive Headlights,Electronic Rear Diff,ARB Bar,Blaupunkt Speakers,JVC Powered Subwoofer,Removable Snorkel,Mitch Hitch,Pioneer After Market Head Unit,Steering Wheel Control Adaptor,Remote Adjustable Supension Rod System, Taxside Dual Battery System.
30th Jan 2007 1:54 pm
DSL Keeper of the wheelie bin
Member Since: 11 May 2006
Location: Off again! :-)
Posts: 73121
You cannot post new topics in this forum You cannot reply to topics in this forum You cannot edit your posts in this forum You cannot delete your posts in this forum You cannot vote in polls in this forum
She was in charge of the bung when I was on the exhaust tube & vice versa, hence not getting a good enough seal. 
p .
