Member Since: 06 Nov 2004
Location: Hook Norton
Posts: 18563
Airbag Warning Light
Classification
Electrical
Problem
It would appear that due to a shortage of airbags, to keep the production line running alternative (Ford) airbags are being fitted to the D3. However, adjusting the front electric (also perhaps non-electric?) seats may stretch the airbag cabling, affecting the electrical connection and causing the airbag warning light to come on and then stay on when the vehicle is started.
Affected vehicles
06MY
Reported
11th September 2005 by zig via PM
Reported Cases
Occurs
On adjusting front seats
Submitted to dealer network
Dealer Response
Submitted to LR Customer Services
LR CS Response Reported
Fix/Solution
- recommend to contact dealer
Other Comments
None
06 D3 SE / 15 LR D90 XS SW / 88 LR 90 Td5 / 68 BMW 2000 ti
Any issues with the site let me know!
11th Sep 2005 10:12 pm
steveho
Member Since: 07 Jan 2006
Location: lincoln
Posts: 74
the only fix at the moment is to replace the side airbag and leave enough slack in the cable to allow the seat to move without stretching the cable
21st Jan 2006 9:10 pm
BCP
Member Since: 25 May 2005
Location: East Scotland
Posts: 1471
Hi, If we use the heated seats it puts the airbag warning light on. Fantastic mechanically - we've given up looking at all the warning messages! Turn it off and on again and all well.
BP
22nd Jan 2006 12:57 pm
steveho
Member Since: 07 Jan 2006
Location: lincoln
Posts: 74
I would get it looked at nonetheless,because while the warning lamp is on the srs would be disabled or partially disabled depending on the severity of the problem
22nd Jan 2006 4:38 pm
Carla
Member Since: 24 Oct 2006
Location: SUSSEX
Posts: 1
Airbag warning light
:cry: My Disco 3 has been back with an airbag warning light fault over 9 times. Every time they send it back saying they found the fault (each time different) 30 miles or so later - back comes the light! She is back with the same fault now. Has anyone ever got this fixed? My Discovery has had too many faults to even list.
24th Oct 2006 5:30 pm
SN
Member Since: 03 Jan 2006
Location: Romiley
Posts: 13710
Welcome to the site Carla - how old is your D3? Sounds like you might be getting in to the realm's of 'handing it back' ... Steve N | 21MY Defender | 08MY Discovery 3 (history) | 06MY Discovery 3 (ancient history)
24th Oct 2006 6:09 pm
Gareth Site Moderator
Member Since: 07 Dec 2004
Location: Bramhall
Posts: 26774
More impotantly which dealer are you using? maybe a different dealer is the answer.
24th Oct 2006 6:37 pm
Happy Chappy
Member Since: 30 May 2006
Location: North Yorkshire
Posts: 6
My wife's TDV6 base had this fault from new. It recurred each time I drove the car but not when she did. Reported to Guy Salmon who claimed to have "fixed" the problem only for it to re-occur next time I drove it. Eventually deduced it was moving the seat base that triggered the problem. Once I told GS this they simply unclipped and reclipped a multiplug under the dreivers seat and "robert is your aunty's husband". All Ok for 3000 miles now (touch wood)God I love these cars!
Now D4 SDV6 Santorini Black facelift Black Pack Sidesteps and Privacy
Ex D4 SDV6 HSE Santorini Black
Ex RRS tvd8 HSE
Ex TDV6 7 seats Zambezi Silver
Is this warning light correctly known as the "SRS warning light" in the manual?
The warning lamp I refer to is seen in the Tacho dial on the RHD models.
I have this problem and twice the dealer has tried to fix it but the light has come back on. I rarely move the drivers seat as I only drive the car however I store a foldable windscreen sunshield under the passenger seat (on the LHS). Could this be fouling any wiring causing the lamp to light up?
My D3 is a Feb 05 build and this problem only occurred about 6 weeks ago.
Thanks
Chris2011 Discovery 4 (MY12) SDV6 HSE with General Grabber AT's, Traxide Aux Battery system, custom rear drawers and Autosafe half height cargo barrier
Gone - 2005 Discovery 3 TDV6 HSE
ARB Bull Bar, Warn 9.5XP Winch, IPF D/Lights, Cooper STT's, LR Raised Air Intake, Traxide aux battery system, custom drawers and half height Autosafe cargo barrier, Mitchell Bros 4x4 tow hitch
The fault was the rotational connector between the steering wheel and sterring column.
So far so good - no more SRS Warning light.
Chris2011 Discovery 4 (MY12) SDV6 HSE with General Grabber AT's, Traxide Aux Battery system, custom rear drawers and Autosafe half height cargo barrier
Gone - 2005 Discovery 3 TDV6 HSE
ARB Bull Bar, Warn 9.5XP Winch, IPF D/Lights, Cooper STT's, LR Raised Air Intake, Traxide aux battery system, custom drawers and half height Autosafe cargo barrier, Mitchell Bros 4x4 tow hitch
22nd Dec 2006 2:01 am
chesters
Member Since: 03 Oct 2005
Location: The Toon
Posts: 698
I have also had this part replaced, the part was over £100, (warranty claim ) I thought they were taking the Mick, but is has been ok since.Arctic Frost Discovery 3 TDV6 SE, Active Rear Diff, Adaptive Head Lights, Tow Pack, Ebony Leather, Roof Rails, Mantec Guard. Tasmod Stainless Sill plates. Grabber AT's. Home made mud flaps. Side Steps back on until the next time.
We had the airbag light problem from new and had the car in a few times. They said that there were bent pins in the connector and each time they adjusted this but it only then worked Ok fro a short time.
Eventually they I think replaced a part (not sure what part) and it has been OK for quite some time now.
9th Jun 2007 1:51 pm
aqua
Member Since: 03 Aug 2009
Location: South Coast
Posts: 1
Hi my airbag warning light seems to randomly come on - sometimes on ignition and stays on, sometimes it goes out on ignition then comes on about 4 mins later and stays on - sometimes it doesn't come on for half an hour..... its become more frequent lately and I'm concerned about driving it longer distances - the dealer cleared the fault some time ago but its out of warranty a long time (end 05 car) - are there any recent experiences of this airbag light problem - and cure ?
3rd Aug 2009 10:12 am
wiggs
Member Since: 03 Sep 2006
Location: Manchester
Posts: 14372
Welcome to the site
Clock spring could well be the issue ..dealer should replace this as it was an issue a while back .
Firstly though check the connector at the bottom of the seat belt tentioner ..it has been known to get snagged on the seat runnerG4 Gone ...but not forgotten
3rd Aug 2009 10:50 am
catweasel
Member Since: 05 May 2006
Location: Bundaleer
Posts: 4805
You cannot post new topics in this forum You cannot reply to topics in this forum You cannot edit your posts in this forum You cannot delete your posts in this forum You cannot vote in polls in this forum
| 08MY Discovery 3 (history) 
