| Home · FAQ · New Posts · My Posts · PMs · Search · Members · Members Map · Groups · Profile · Donate ·
Log In
|
- You are currently viewing DISCO4.COM as a guest - Register to take part or Log In
Silverc
Member Since: 10 Mar 2012
Location: Surrey
Posts: 14
  
|
| D4 turbo - noise from left turbo |
|
I was hoping someone may have experience of this problem and ho hopefully the solution wasn’t to have a new turbo installed. When the car is cold and I rev to about 2000 revs there is a brief whine which sounds almost like a squealing pulley belt. The noise occurs before and up to 2000rpms. The noise goes away when the car is warm however I have had a restricted performance warning (red triangle) a few times. There is no excess smoke coming out or oil leaking. The noise is definitely coming from the left side of the car (primary turbo). The Indy looked at the car and said it was a turbo fault and the turbo was on its way out.
Is this the start of a failing turbo or could it be the actuator which could be remedied?
I took off the heat shields and sprayed Q20 where I think the actuator is hidden behind the turbo, but it hasn’t made a difference.
Any advice appreciated.
Last edited by Silverc on 21st Jul 2019 4:31 am. Edited 1 time in total
|
 13th Jul 2019 8:04 am |
|
|
grzesiul
Member Since: 11 May 2008
Location: UK
Posts: 6398
 
|
first read DTC codes to in point the problem as were would be some registered if you getting restricted perf
where are you located
Greg
|
| 13th Jul 2019 8:16 am |
|
|
Silverc
Member Since: 10 Mar 2012
Location: Surrey
Posts: 14
|
Thanks Greg. Unfortunately I don’t have a fault code reader ....and am a bit out the way in South Africa. Will try get the exact code from the Indy..
|
| 13th Jul 2019 11:14 am |
|
|
Brucey
Member Since: 24 Oct 2015
Location: Bedfordshire
Posts: 137
|
Your not in Pretoria are you? I'll be down there later this week and I could bring my IID tool.
|
| 13th Jul 2019 12:48 pm |
|
|
Silverc
Member Since: 10 Mar 2012
Location: Surrey
Posts: 14
|
Thanks Brucey - I am in Durban
|
| 13th Jul 2019 4:16 pm |
|
|
Brucey
Member Since: 24 Oct 2015
Location: Bedfordshire
Posts: 137
|
Ah that's a shame. Hope you get it sorted
|
| 14th Jul 2019 4:17 am |
|
|
Dave T
Member Since: 03 Jul 2009
Location: Glasgow
Posts: 6910
|
It’s worth buying a code reader, you only need to use it a couple of times to get your money back if you go the cheap route and get something like an icarsoft at around £150 in the uk Joined the BMWX5 45e group
1994 Defender 90
2015 RRS Corris Grey/Black roof
2016 D4 Graphite Santorini Black
2012 D4 XS Orkney Grey
2005 D3 S Maya Gold
Convoy for Heroes 2011
|
| 14th Jul 2019 4:40 am |
|
|
Silverc
Member Since: 10 Mar 2012
Location: Surrey
Posts: 14
|
Thanks Dave - I will look into that.
1 question - if I get a reader and get the codes, where do I find the translation/meaning of the codes?
Does anyone know if the sticking actuator can be fixed on the D4? Assuming that is the problem.
|
| 17th Jul 2019 7:56 am |
|
|
DiscoJeffster
Member Since: 27 Feb 2016
Location: Perth
Posts: 204
 
|
Google disco and the code. Simples.
|
| 17th Jul 2019 3:01 pm |
|
|
Flack
Member Since: 06 Sep 2006
Location: Preston Lancashire
Posts: 6308
 
|
When you say the left turbo, is that the secondary turbo you are on about, if so check your TSOV, its probably sticking/stuck. This turbo only comes in at the rpm your reporting and this TSOV valve stays shut you get the type of noise your reporting.
Check all the small vac pipes on the front of the engine to make sure they are all on, if so you need to check this valve out.
Its a common fault with it.
Flack 
|
| 17th Jul 2019 4:52 pm |
|
|
Silverc
Member Since: 10 Mar 2012
Location: Surrey
Posts: 14
|
Hi - thanks Flack... the problem unfortunately is by the primary turbo (the variable vane turbo)...
|
| 21st Jul 2019 4:29 am |
|
|
Silverc
Member Since: 10 Mar 2012
Location: Surrey
Posts: 14
|
Hi - some further information and request for advice:
1. So I took the car to another mechanic, and on the way to them the restricted performance light came on (red triangle) and the car power was reduced... no smoke or noise though.
2. At the mechanic, the following error codes were evident - P22D2 - turbo charger turbine inlet valve stuck open; and P22CF -Turbine inlet valve control circuit - open
When starting the car again, and revving it to 2000 rpm quickly, the noise (whine) was evident for a second or two on the left hand side turbo - sitting in the car facing forward - which is the primary turbo.
From reading around, it seems that most people with these symptoms have an issue with the secondary (right side) turbo. This doesn't seem to be the case with my issue based on the above. I also don't have any noises or issues above 2800 rpm (when the 2nd turbo kicks in).
The mechanic suggested the following steps to remediate:
1. It is likely that the noise is coming from the manifold and may be solved by replacing the gasket. He doesn't recommend skimming the manifold as this can lead to cracks later on, but says the gasket will solve the noise.
2. The error messages are likely to be caused by a leak in one of the air pipes and he is going to do a vacuum test to prove, or the solenoids may need to be changed.
Does this sound about right?
Anyone have any views on the manifold skimming?
Should the CAT be checked and possibly removed as it may be blocked?
Thanks for any advice.
|
| 23rd Jul 2019 8:09 am |
|
|
LR4REPDOM
Member Since: 07 Aug 2023
Location: Punta Cana
Posts: 1
|
Hello Silverc:
I am experiencing the exact same problem with the turbo noise (whine) in the left side of the engine. I have changed both turbos and the problem was gone for a while. My joy lasted just 2 or three days.
Could you tell me if the noise was gone after you changed the inlet manifold gasket??
Thank you in advance.
|
| 25th Jan 2024 6:13 pm |
|
|
|
Posting Rules
You cannot post new topics in this forum
You cannot reply to topics in this forum
You cannot edit your posts in this forum
You cannot delete your posts in this forum
You cannot vote in polls in this forum
|
|
|
DISCO4.COM Copyright © 2004-2024 Futuranet Ltd & Martin Lewis
|
|
DISCO4.COM is independent and not affiliated to Land Rover.
