I'm planning on using brake cleaner - that's designed to evaporate pretty quick and does a good job of removing gunk! Now an ex-D3 owner after 7 happy years. Miss the car but not the big bills
15th Apr 2011 6:42 am
chalky
Member Since: 21 Aug 2008
Location: Yorkshire
Posts: 3145
There seems to be NO common denominator !
I was looking at several posts thinking that 2007 on were cleaner ?
Maybe because of the the fact that EGR's cannot be removed from the later ones, but the above post conforms a 2008 one is gunked up too ?
Obviously a 2007 / 08 and on will be cleaner due to the fact it hasnt seen as many start / stops, winter starts etc etc but they appear to be all of a muchness, with the odd exception and then the ones with EGR's removed ?
15th Apr 2011 7:55 am
peterm
Member Since: 28 Sep 2009
Location: sweden
Posts: 114
To clarify on my post above : It looked a lot like Rentons picture on page 5, entry hole not blocked but the rest was a nasty sticky mess. Cleaned down the hole with contact cleaner and it took maybe 5 attempts until the liquid coming out was clean. Didnt notice any difference in driving though, but then again I didnt have any symptoms like the ones desceibed here to start with.
Removed and inspected today - gunky but not as bad as some. EGR's blanked late last year ..........
Cleaned up courtesy of Tawneyowl and having driven circa 70 miles since distinct improvement on pick up from standing start and under acceleration. Gonna be keeping an eye on this with some regularity.
15th Apr 2011 3:54 pm
mik
Member Since: 08 Feb 2010
Location: Skoatland
Posts: 912
Just cleaned. Looked very like DSL's original pic - gunky but aperture still clear (slighly occluded by gunk)
EGRs blanked last year, but I didn't clean this at the time..... will have another look in a few weeks.
15th Apr 2011 4:20 pm
chalky
Member Since: 21 Aug 2008
Location: Yorkshire
Posts: 3145
Mines a 57 Plate with 37,500 on the clock
Mine was gummed up but the aperture was free, cleaned it off and washed it out with contact cleaner and it picks up smoother and on gear change "manual" it doesent drop the revs as much and pick up and engine braking appear smoother / linear ?
15th Apr 2011 4:31 pm
MikeS2005
Member Since: 13 Sep 2008
Location: Midlothian
Posts: 920
all gumed up
Hi
Mine was covered in black sludge it looked like it had been melted cleaned it with brake cleaner and all is now new again cant say its made any difference though
cheers
15th Apr 2011 10:04 pm
DaveT
Member Since: 01 Aug 2005
Location: Cornwall
Posts: 2576
Mine's an 08MY manual. EGR's not blanked (cos I cant)
It's had EGR's and the sensor changed in the past (couple of years ago).
Sensor was totally gunked, with a soft gooey black pooh.
Would this actually affect the sensor?? I reckon it could still pick up a difference in pressure through that stuff.
Having now driven it a few times, I'd say it's a little better, but it's as if there's still another sensor suffering from the same thing. Thing I'll now take it for a nice long blast to clean it out. Morocco should do the trick Long succession of Disco's since 2001...
SIII Lightweight - neglected & rusting. Bulkhead, A panels, vent panel & outriggers now disintegrated - Next years project!
16th Apr 2011 6:55 am
discoBizz
Member Since: 20 Sep 2008
Location: Manchester
Posts: 1416
Just done this, can't say it was as bad as others (27k miles on the clock, MY08 so EGRs NOT blanked):
Click image to enlarge
After a good wipe, cleaning the inside with a pin and some WD40 which I swished around and thoroughly died (I also used a short burst from one of my scuba tanks, at an angle):
Click image to enlarge
(just couldn't get the camera to focus )
Interesting to note the part is made by Hitachi:
Click image to enlarge
For those who are about to do it, also note the torx is a T25
Member Since: 23 Aug 2007
Location: Kent
Posts: 10564
Just a thought but has anyone looked at a D4 one yet?MY17 D5 1st Edition Namib Orange
MY15 D4 HSE Kaikoura Stone
MY12 D4 HSE Nara Bronze Sold and gone
MY11 D4 HSE Stornaway Grey Sold and gone
D3 S spec Silver Sold and gone
Tow bar, full length roof bars, side steps, tow bar storage unit, surround camers.
D4 camera club
16th Apr 2011 10:41 am
dazsear
Member Since: 25 Jan 2011
Location: Lincolnshire
Posts: 371
Did my 09 50k car yesterday, very light gunk on the edge but the hole was clean.
No difference once done but I will check again in 6 months.
Daz17 4.4 Autobiography FFRR
57 VW Transporter - now gone!
09 D3 HSE in Black - long gone!
08 RRS TDV8 HST - long long gone!
16th Apr 2011 11:13 am
NIDisco3
Member Since: 28 Apr 2005
Location: Derry City
Posts: 610
Just done this clean up.
My car is an 05 HSE, 84k and EGR's blanked since last summer (75k)
Before:
After:
Havnt been out in the disco yet since cleaning this up, but will report back soon
16th Apr 2011 2:35 pm
DSL Keeper of the wheelie bin
Member Since: 11 May 2006
Location: Off again! :-)
Posts: 73089
You cannot post new topics in this forum You cannot reply to topics in this forum You cannot edit your posts in this forum You cannot delete your posts in this forum You cannot vote in polls in this forum
)
