Member Since: 27 Mar 2008
Location: Riyadh, KSA
Posts: 3079
Major fuel leak
Diesel p g out from under D4 luckily almost right outside my mates house. Nothing visible under the bonnet it's all from underneath. Now dripping front to back off the chassis where it's leaked so will have to sand the road.
What's the usual suspects?D4 XS, gone, much loved, never forgotten
2018 FFRR SDV8 Autobiography - Gone to someone with less sense and more time to enjoy it
2016 Toyota Hilux Invincible - Liberating experience
30th Apr 2017 4:32 pm
James W
Member Since: 27 Mar 2008
Location: Riyadh, KSA
Posts: 3079
Useless recovery guy said it's under the undertray that runs front to back on the offside. To the rear of the engine, running a down towards the back I know door
But he claimed he couldn't get it off. Is the fuel filter under there? I think it must be the fuel filter that's leaking. It starts leaking when the ignition is on, even without the engine running. Any help or ideas appreciated.
Tempted to try and drop the tray here at my mates before trying to arrange recovery.D4 XS, gone, much loved, never forgotten
2018 FFRR SDV8 Autobiography - Gone to someone with less sense and more time to enjoy it
2016 Toyota Hilux Invincible - Liberating experience
30th Apr 2017 7:46 pm
Russy
Member Since: 31 Dec 2015
Location: Lancashire
Posts: 63
Sounds like he's describing the fuel tank cradle, I think the pump is in the tank.
30th Apr 2017 8:33 pm
James W
Member Since: 27 Mar 2008
Location: Riyadh, KSA
Posts: 3079
I didn't realise the fuel tank was under that. So it could be any of these components leaking?!
D4 XS, gone, much loved, never forgotten
2018 FFRR SDV8 Autobiography - Gone to someone with less sense and more time to enjoy it
2016 Toyota Hilux Invincible - Liberating experience
30th Apr 2017 10:35 pm
lynalldiscovery
Member Since: 22 Dec 2009
Location: Maidstone
Posts: 7274
You sure thats a D4 tank image looks D2 to me?
Could it be as simple as the fuel filter water drain screw is loose/damaged?
The yellow knurled bit
1st May 2017 6:01 am
James W
Member Since: 27 Mar 2008
Location: Riyadh, KSA
Posts: 3079
I think you're right about the D2 tank. Google fail there.
Hopefully it's something obvious and visible. It had its 7 year service a couple of weeks ago so presumably the filter was changed then.
It's being recovered home at 11, I plan to take a look at home where I have tools.D4 XS, gone, much loved, never forgotten
2018 FFRR SDV8 Autobiography - Gone to someone with less sense and more time to enjoy it
2016 Toyota Hilux Invincible - Liberating experience
1st May 2017 7:08 am
dgardel
Member Since: 03 Nov 2009
Location: Greater Venice
Posts: 2025
Member Since: 20 Dec 2008
Location: Saddleworth Oldham
Posts: 1954
Have you just filled it up James ?
I had the same on mine and it was the fuel sender seal and only noticed it when parked on a hill !
Hope you get it sorted what ever it is MY18 D5 HSE LUX😎
MY12 Freelander SD4 HSE
44 Tonne 12 Litre 6x2 Scania T cab (Current)
Freelander 1 (Wrote off 😫)
Ex D1
Ex D2 GS
Ex V8 D2 GS
Ex D3 S
Ex D4 GS
Club skip ya lockers !!!
Club BAS remote heater !!
Club Duratrac
Club Phillips DRL
Club Prospeed Rack Mk 1
Club Prospeed Rack Mk 2
Club Sankey
Club RLD spare wheel protector
1st May 2017 7:59 am
moorman
Member Since: 05 Jul 2009
Location: East Anglia
Posts: 276
Thirsty mice!
1st May 2017 8:06 am
James W
Member Since: 27 Mar 2008
Location: Riyadh, KSA
Posts: 3079
It was parked in a field all weekend
The tank is about 3/4 full. Thanks for the diagram, the recovery is due in about 30 mins from my mates and hopefully it will stop raining enough for me to take a look at home D4 XS, gone, much loved, never forgotten
2018 FFRR SDV8 Autobiography - Gone to someone with less sense and more time to enjoy it
2016 Toyota Hilux Invincible - Liberating experience
1st May 2017 9:27 am
lynalldiscovery
Member Since: 22 Dec 2009
Location: Maidstone
Posts: 7274
The clue will be the fact its just been serviced so something left loose or knocked, hopefully cheap/simple fix
I was always told thats the most dangerous time in any vehicles life right after its been worked on.
1st May 2017 1:55 pm
James W
Member Since: 27 Mar 2008
Location: Riyadh, KSA
Posts: 3079
Okay had the middle plastic undertray and the heat shield around the fuel filter off. The plastic water drain off has slipped it's thread and is loose, and can not be tightened even after removing the filter cartridge itself. Looks like a faulty part or has been over tightened on installation.
Have left underpanels off on the drive and will call servicing garage first thing. Would hope they send someone out with a part to resolve tomorrow.
Got lots of diesel drips on the drive and the car stinks
Thanks for all the support and ideas chaps D4 XS, gone, much loved, never forgotten
2018 FFRR SDV8 Autobiography - Gone to someone with less sense and more time to enjoy it
2016 Toyota Hilux Invincible - Liberating experience
1st May 2017 4:40 pm
James W
Member Since: 27 Mar 2008
Location: Riyadh, KSA
Posts: 3079
Closure on this one - the garage came out and rectified it on my drive. During servicing, they had refitted the yellow water sensor to the new filter (apparently normal practice) but the yellow thread on the screwed-in section of it had subsequently completely snapped on Sunday, causing the leak and meaning it wouldn't stay in the filter. New filter and sensor fitted, no charge (not that I would have expected to pay anything!)
Going off to local jetwash later to give the underneath a good spray, we have left the undertray off for now to try and get rid of as much diesel as possible.
Will be paranoid about it when driving for approximately 3 months now going forward
James
PS - lynalldiscovery wins the prize D4 XS, gone, much loved, never forgotten
2018 FFRR SDV8 Autobiography - Gone to someone with less sense and more time to enjoy it
2016 Toyota Hilux Invincible - Liberating experience
2nd May 2017 2:00 pm
DaveJLBI
Member Since: 07 Mar 2014
Location: Clare
Posts: 682
Hi there, I have just similar situation. And a day or two after a service. Disco is on the drive and it happened just as I neared home as well.
How can I find that diesel filter? Will go out and look now
9th Jun 2024 3:12 pm
DaveJLBI
Member Since: 07 Mar 2014
Location: Clare
Posts: 682
Disco went off on the back of a truck today and I collected it this evening. Small water drain at filter to blame, but as the filter was changed as part of full service last Friday, hard not to think that it shouldn't have happened.
So as a result of someone not tightening it, I had to arrange transport of the Disco 30 miles to the garage (LR Indie), luckily my insurance covered that. Then I need to deal with my rive way which is now quite stained from the leak. Plus more than quarter tank gone through the leak, partly on my drive, partly on the back of the tow truck as it drove up and then whatever they lost at the garage.
Not to mention the time involved making other arrangements etc today and then having to get a lift from home to the garage to retrieve it when they were finished. Luckily it was after closing time and they had left the key in the shop on the forecourt.
You cannot post new topics in this forum You cannot reply to topics in this forum You cannot edit your posts in this forum You cannot delete your posts in this forum You cannot vote in polls in this forum
g out from under D4 luckily almost right outside my mates house. Nothing visible under the bonnet it's all from underneath. Now dripping front to back off the chassis where it's leaked so will have to sand the road.
